Cloning and Characterization of an Endoglucanase Gene from Actinomyces sp. Korean Native Goat 40

Article information

Asian-Australas J Anim Sci. 2016;29(1):126-133
Publication date (electronic) : 2015 November 16
doi : https://doi.org/10.5713/ajas.15.0616
Department of Animal Resources Technology, Gyeongnam National University of Science and Technology, Chinju 660-758, Korea.
1Department of Biochemistry, Institute of Cell Differentiation and Aging, College of Medicine, Hallym University, Chuncheon 200-702, Korea.
2CSIRO Animal, Food and Health Science, Queensland Bioscience Precinct, St. Lucia, QLD 4067, Australia.
3Department of Biological Science, Silla University, Busan 617-736, Korea.
4Institute of Green-Bio Science and Technology, Seoul National University, Pyungchang 25354, Korea.
5Department of Animal Science and Technology, Sunchon National University, Sunchon 540-742, Korea.
*Corresponding Author: Kwang Keun Cho. Tel: +82-55-751-3286, Fax: +82-55-751-3689, E-mail: chotwo2@daum.net
Received 2015 July 26; Revised 2015 October 09; Accepted 2015 November 14.

Abstract

A gene from Actinomyces sp. Korean native goat (KNG) 40 that encodes an endo-β-1,4-glucanase, EG1, was cloned and expressed in Escherichia coli (E. coli) DH5α. Recombinant plasmid DNA from a positive clone with a 3.2 kb insert hydrolyzing carboxyl methyl-cellulose (CMC) was designated as pDS3. The entire nucleotide sequence was determined, and an open-reading frame (ORF) was deduced. The ORF encodes a polypeptide of 684 amino acids. The recombinant EG1 produced in E. coli DH5α harboring pDS3 was purified in one step using affinity chromatography on crystalline cellulose and characterized. Sodium dodecyl sulfate-polyacrylamide gel electrophoresis/zymogram analysis of the purified enzyme revealed two protein bands of 57.1 and 54.1 kDa. The amino terminal sequences of these two bands matched those of the deduced ones, starting from residue 166 and 208, respectively. Putative signal sequences, a Shine–Dalgarno-type ribosomal binding site, and promoter sequences related to the consensus sequences were deduced. EG1 has a typical tripartite structure of cellulase, a catalytic domain, a serine-rich linker region, and a cellulose-binding domain. The optimal temperature for the activity of the purified enzyme was 55°C, but it retained over 90% of maximum activity in a broad temperature range (40°C to 60°C). The optimal pH for the enzyme activity was 6.0. Kinetic parameters, Km and Vmax of rEG1 were 0.39% CMC and 143 U/mg, respectively.

INTRODUCTION

There is great interest in using huge amounts of cellulosic biomass, broken down into sugars, as a renewable source. Cellulases have potential applications in various areas, such as the livestock, food, pharmaceutical, textile, detergent, chemical, and fuel production industries. For efficient biological conversion of cellulosic biomass into value-added products or application of cellulose-degrading enzymes, the molecular cloning of cellulolytic enzyme genes with high activity is of the utmost importance. The bioconversion of cellulose into glucose requires the actions of three types of enzymes: a cellulase enzyme complex, including endo-β-1,4-glucanase, cellobiohydrolase, and β-glucosidase (Coughlan, 1985). Among these, endo-β-1,4-glucanase (1,4-β-D-glucan glucanohydrolase; EC 3.2.1.4) attacks cellulose chains at random, breaking internal bonds into smaller fragments, and progressively generating nonreducing ends on which cellobiohydrolase can act. Numerous studies have described endo-β-1,4-glucanase genes in bacteria and fungi (Gilkes et al., 1991). Members of the industrially important Bacillus also produce endo-β-1,4-glucanase, and the genes encoding these enzymes have been cloned and characterized (Lee and Pack, 1988; Baird et al., 1990; Lemaire and Beguin, 1993; Miyatake and Imada, 1997). The rumen in ruminants is an especially active site for the fermentation of cellulose. The most abundant cellulolytic ruminal bacteria include Ruminococcus albus, Fibrobacter succinogenes, Ruminococcus. flavefaciens, and Butyrivibrio fibrisolvens (Forsberg, 1993; Malburg and Forsberg, 1993; Sahu et al., 2004). The first isolation and identification of a novel anaerobic cellulolytic Actinomyces sp. from rumen of Korean native goat was reported by Park (Park et al., 1993). This bacterium having high carboxy methyl cellulase (CMCase; endoglucanase) activity was one of the predominant species in the rumen of Korean native goat and secreted considerable amounts of the enzyme into the culture supernatant (Park et al., 1993; Min et al., 1994).

For potential industrial applications, we had previously conducted extensive screening tests to isolate bacterium with high cellulose activity from rumen of Korean native goat (KNG). After a series of experiments, we reported isolation and identification of cellulolytic Antinomyces sp. KNG 40 having the highest cellulolytic activity of isolates tested and characterization of endo-β-1,4-glucanase (Min et al., 1994a,b). Molecular cloning of novel and powerful cellulase genes might be very important for the successful production and industrial application of the enzyme. For this reason, this study was performed to clone novel and powerful cellulase genes from Antinomies sp. KNG 40 and to characterize purified recombinant cellulase enzyme for industrial applications. To the best of our knowledge, complete molecular cloning, sequencing and biochemical characteristics of cellulase from the Actinomyces have not been reported yet.

Here, we report, for the first time, the cloning and nucleotide sequences analysis of a novel endo-β-1,4-glucanase gene from Actinomyces sp. KNG 40 isolated from the rumen of KNG, and the enzyme properties of an endo-β-1,4-glucanase when expressed in Escherichia coli (E. coli) DH5α.

MATERIALS AND METHODS

Bacterial strains and media

Ruminal fluid was collected from the rumen of KNGs through a cannula to isolate cellulose-degrading bacteria. The collected ruminal fluid was filtered through cheesecloth and diluted with an anaerobic dilution solution using an anaerobic culture system. The colonies were then isolated by the roll-tube method. Actinomyces sp. KNG 40 was anaerobically grown at 37°C on Dehority’s artificial medium containing 0.2% cellobiose. E. coli DH5α was grown aerobically in Luria-Bertani (LB) medium at 37°C or on an LB plate, supplemented with ampicillin (50 μg/mL) for transformants.

Construction of a genomic DNA library and cloning of endoglucanase

The pUC19 plasmid and E. coli DH5α were used as the vector-host system for cloning. Chromosomal DNA of Actinomyces sp. KNG 40 was prepared from the cells in the early exponential growth phase following the method of Saito and Miura (1963). Plasmid DNA was prepared by the alkali lysis method (Sambrook et al., 1989). Competent cells of E. coli were prepared by the calcium chloride method (Sambrook et al., 1989). Chromosomal DNA of Actinomyces sp. KNG 40 was partially digested with Sau3AI and separated by sucrose density gradient centrifugation (10% to 40% w/v). DNA fragments of 2 to 8 kb were collected and ligated into the BamH I site of the pUC19 vector. The ligation products were transformed into competent E. coli DH5α, and transformants were selected for by plating on LB agar plates, supplemented with X-gal (5-bromo-4-chloro-3-indolyl-galactoside) and ampicillin at 37°C for 12 to 14 h. Clones expressing endoglucanase activity were detected by replica plating the bacterial colonies onto LB containing 0.5% carboxymethyl cellulose (CMC) and ampicillin. The plates were incubated at 37°C for 16 to 24 h. The plates were then flooded with a 0.1% aqueous solution of Congo red (Sigma, St. Louis, MO, USA) (Teather and Wood, 1982) for 30 min. Unbound dye molecules were removed by reflooding the plates with 1 M NaCl for 15 min. The formation of visible halos around the colonies indicated the production of endoglucanase.

DNA sequence analysis

DNA sequences were determined by the chain termination method of Sanger et al. (1997) using a PRISM-ready reaction dideoxy terminator cycle sequencing kit (Perkin Elmer, Boston, MA, USA) with supercoiled plasmids as templates. The DNA sequences were analyzed using the PC/GENE software package (V. 6.60, IntelliGenetics Inc., Mountain View, CA, USA).

Purification and N-terminal amino acid sequence analysis of an endoglucanase produced by E. coli DH5α

An endoglucanase produced by E. coli DH5α containing pDS3 was purified by a crystalline cellulose (Avicel PH-101; Fluka Chemie GmbH, Buchs, Switzerland) column. The cultured cells were harvested at an early stationary phase by centrifugation at 3,400× g for 10 min, and the supernatant was used as a crude enzyme source. The enzyme solution was concentrated using ultrafiltration on an Amicon YM-10 membrane (MW cut-off: 10,000) in an Amicon model 8400 (Millipore, Bedford, MA, USA) stirring ultrafiltration cell under 20 psi of N2. The solution was concentrated by ultrafiltration at each purification step, if necessary. The concentrated enzyme was placed in a crystalline cellulose column (20 mL bed volume) using a BioLogic System (Bio-Rad, Hercules, CA, USA). Bound proteins were eluted with double-distilled water and then buffer exchanged into 20 mM Tris-Cl, pH 7.4. The purified endoglucanase (3.0 μg/well) was separated on a 10% sodium dodecyl sulfate-polyacrylamide gel electrophoresis minigel at 200 V using a Bio-Rad Mini-PROTEAN cell. Proteins were electroblotted at 70 V for 1 h with water cooling onto a Trans-Blot polyvinylidene fluoride membrane (Bio-RAD Laboratories, USA). The membrane was immersed in 0.025% Coomassie Blue R-250 for 5 min and destained with 50% methanol for 15 min. The membrane was then washed with a large volume of distilled water with several changes. The protein band was cut out, and the N-terminal amino acid of the protein was microsequenced using an Edman Gas Phase Microsequencer (Model ALI 473a; Applied Biosystems Inc., Foster city, CA, USA).

Distribution of enzyme

The fractionations of extracellular, periplasmic, cell-bound, and intracellular enzymes were performed as described by the methods of Min et al. (1994a).

Enzyme assays

Carboxymethyl cellulase (CMCase, endoglucanase) activity was measured as the amount of reducing sugars released from 0.7% CMC in a 50 mM sodium citrate buffer (pH 6.0) at 55°C for 30 min. Reducing sugars were measured by the Somogyi-Nelson method (Somogyi, 1952) with glucose as a standard. One unit of enzyme activity was defined as that forming 1 μmole of glucose equivalent of reducing sugar per minute under the standard conditions. The modified dye-binding method of Bradford (1976) was used for the determination of protein concentrations, with bovine serum albumin as a standard. Enzyme kinetics were studied on a CMC substrate of 0.16% to 1% concentration in a 50 mM sodium citrate buffer (pH 6.0) at 55°C for 30 min. From linear plots of the Michaelis–Menten equation such as Lineweaver-Burk or Hanes-Woolf plot using an Excel curve-fitting program (Microsoft Excel 2010, San Francisco, CA, USA), kinetic parameters, Km and Vmax of recombinant EG1 was calculated.

Proteins were analyzed by sodium dodecyl sulfate-polyacrylamide gel electrophoresis (SDS-PAGE) using the method of Laemmli (1970). The proteins were stained with Coomassie Brilliant Blue R-250.

RESULTS AND DISCUSSION

Gene cloning of an endoglucanase from Actinomyces sp. Korean native goat 40

The genomic library was constructed by ligating 2 to 8 kb Sau3AI fragments of Actinomyces sp. KNG 40 DNA into the BamHI site of pUC19. To isolate endoglucanase genes, clones expressing endoglucanase activities were detected by replica plating the bacterial colonies onto an LB (with ampicillin) plate containing 0.5% CMC. Among the 1,250 clones screened, 10 were identified as endoglucanase positive based on the formation of visible halos around the colonies. Only one of the endoglucanase-positive clones was identified and confirmed as having assayable endoglucanase activities. A recombinant plasmid harboring a 5.0 kb insert from this clone was designated as pDS1. Various restriction fragments from pDS1 were subcloned into pUC19 vectors, and endoglucanase activity was determined on the CMC plate. E. coli clones containing pDS3 (3.2 kb insert) showed the highest endoglucanase activity (Figure 1). It has been shown conclusively that most cellulolytic microorganism produces the isomeric forms of cellulase and xylanase with similar substrate specificities, which are the products of large multigene families but not the result of post-translational modification of a single enzyme (Malburg and Forsberg, 1993; Bedford and Partridge, 2001; Nguyen et al., 2012, Rashamuse et al., 2013). Therefore, this clone might be one of multiple cellulase genes from Actinomyces sp. KNG 40.

Figure 1

Mapping and subcloning of the cloned endo-β-1,4-glucanase gene (pDS1).

Nucleotide sequence analysis

The 2,641 bp fragment of pDS3 was fully sequenced. It contained an open-reading frame of 2,066 bps, starting with ATG and terminating with a TGA stop codon encoding a protein of 688 amino acids, with a calculated molecular mass of 75,753 Da. A putative ribosome-binding site (Shine-Dalgarno sequence) was located 5 bps upstream from the initiation codon (Shine and Dalgano, 1975). CTTGAC and TTATC sequences located at positions 80 and 113 nt, respectively, upstream from the Shine-Dalgarno sequence corresponded to the putative utative ns 80 and 113ion of a single A putative catalytic domain and a cellulose-binding domain were found between 872 and 1,851 and between 1,920 and 2,252, respectively, the domains were connected by a Ser- and a Thr-rich linker region between 1,852 and 1,919. Comparison of the deduced amino acid sequence of the endoglucanase gene with that of other endoglucanases compiled in GenBank revealed sequence homology to family 5 (family A) glycosyl hydrolases (Table 1). Genes encoding for cellulase enzymes from a variety of rumen bacteria have been cloned and sequenced, and their amino acid sequences have been deduced (Pollle et al., 1990; Mittendorf et al., 1993; Cho et al., 2000; Nguyen et al., 2012). However, to our knowledge, molecular cloning, sequence analysis and characterization of cellulase gene from anaerobic rumen bacterium Actinomyce sp., has not been reported so far. This is the first report of the cloning and sequence analysis of an endoglucanase gene from rumen bacterium Actinomyce sp. No DNA sequence similarity was identified with the published endoglucanase from a variety of bacteria. The GenBank accession number of the cloned endoglucanase is U94825.

Comparison of the amino acid sequences of the endoglucanase in this study with those various family 5 endoglucanases1

Purification and N-terminal sequence analysis of endoglucanase produced by E. coli DH5α

Fungal cellulases are usually released from the cell (Areej et al., 2014). Although generally bacterial enzymes seem to remain with cell, cellulases from some of anaerobic rumen bacteria may be secreted by the cell (Clarke, 1997). For examples, endoglucanases from some rumen bacteria including Clostridium sp., Fibrobacter succinogenes, and Bacillus licheniformis were reported to be secreted into the culture medium (Mittendorf and Thomson, 1993; Cho et al., 2000; Seo et al., 2013). In this study, two-thirds of the endoglucanase enzyme was secreted into the Actinomyces culture medium. About 40% of the recombinant enzyme was fully secreted into the culture medium when it was expressed in E. coli containing pDS3 (Table 2). It means that the secretion ability of the signal peptide of the endoglucanase is more powerful than others, and the secreted recombinant enzyme in E.coli can be used in many industrial applications including animal feed industry (Kuhad et al., 2011; Gao et al., 2015). A recombinant endoglucanase EG1 was purified from the culture medium of E. coli DH5α containing pDS3 in one step in a microcrystalline cellulose (Avicel PH-101; Fluka Chemie GmbH, Buchs, Switzerland) column. The specific activity of the purified EG1 was 56.7 U/mg protein.

Localization of endo-β-1,4-glucanase activity (in %) in Actinomyces sp. Korean native goat 40 and Escherichia coli (E. coli) DH5α

The SDS-PAGE/zymogram technique using the fluorogenic substrate methylumbelliferyl cellobioside (MUC) was used to separate and detect two major band showing endoglucanase activity from the purified enzyme. An active protein bands having an approximate molecular weight (MW) of 51.4 and 57.1 kDa, respectively, were detected on Laemmli gel under UV illumination (data not shown) (Figure 2). The ratio of the activity and the protein band intensity of the two bands were very similar.

Figure 2

SDS-PAGE of EG1. The gel was stained with Coomassie Blue R250. Endoglucanase (EG1) was identified using an MUC zymogram assay (data not shown). M, Protein molecular markers; lane 1 (10 μL) and lane 2 (2 μL) from fraction E1 and lane 3 (10 μL) and lane 4 (2 μL) from fraction E2 of the microcrystalline cellulose column eluent. SDS-PAGE, sodium dodecyl sulfate-polyacrylamide gel electrophoresis.

The N-terminal sequences of these two bands analyzed by Edman degradation method matched those of the deduced sequences, starting from residue 166 and 208, respectively (Figure 3). The cleavage site of the recombinant endoglucanase by signal peptidase obey the “(−3, −1) rule”: the residue at position −1 must be small and uncharged (Ala, Ser, Gly, Cys, Thr, Gln, Pro, or Leu), and also the residue at position −3 is always a small and uncharged (Ala, Ser, Gly, Cys, Thr, Ile, Leu, or Val) (Perlman and Halvorson, 1983; Von Heijne, 1985; Yan and Wu, 2014). It indicates that these preceding amino acids play a signal peptide-like role. The cellulose-binding domain starts from residue 166 or 208.

Figure 3

Nucleotide sequence of the 2,641 bp Sal I/Pst I restriction fragment of pDS3. The putative promoter sequence and ribosome-binding site are underlined. The deduced amino acid sequence for the endoglucanase is shown under the nucleotide sequence. Two amino terminal sequences determined for the recombinant endoglucanase are underlined. The Ser- and Thr-rich linker region is shown in the box.

Characterization of purified endoglucanase produced by E. coli DH5α

Table 3 shows the substrate specificity of endoglucanase. Many studies have reported that a large number of cloned cellulases from rumen bacteria possess bifunctional endoglucanase-xylanase activities (Cho et al., 2000; Chang et al., 2011; Rashamuse et al., 2013; Yuan et al., 2015). The purified endoglucanase from our study showed the highest enzyme activity against CMC but weak enzyme activity was observed for xylan, avicell, and cellobiose (Table 3). This result is consistent with previous studies of Actinomyces sp. (Min et al., 1994).

Substrate specificity of endoglucanase from Escherichia coli DH5α harboring pDS3

The optimum temperature of the enzyme activity was determined by assaying the endoglucanase activities at various temperatures for 30 min in a 50 mM sodium citrate buffer (pH 6.0) with 0.7% CMC. The optimal temperature of the purified enzyme was 55°C, but it retained over 90% of maximum activity in a broad temperature range (40°C to 60°C). The enzyme activity decreased rapidly above 65°C but the enzyme still retained 60% of its maximum activity even at 70°C (Figure 4). In general, endoglucanases from fungi and bacteria are stable at temperature below 55°C (Ohara et al., 2000; Nguyen et al., 2012; Culleton et al., 2014). This result suggests that the cloned endoglucanase from Actinomyces sp. KNG 40 is more thermostable and active at high temperature.

Figure 4

Temperature-activity profile of the endoglucanase. The assay was performed for 30 min in a 50 mM sodium citrate buffer (pH 6.0) with 0.7% carboxyl methyl-cellulose.

The effects of pH on the activity were determined by varying the pH of the reaction mixture using a 50 mM sodium citrate buffer (pH 3.0 to 6.0) and 50 mM sodium phosphate buffer (pH 6.0 to 8.0) with 0.7% CMC at 45°C for 30 min. The optimal pH for the enzyme activity was 6.0 (Figure 5). This result is consistent with previous reports. Many studies have reported that the optimal pH for the cloned endoglucanases activity from various cellulolytic rumen bacteria was in the range of pH 5.0 to 7.0 (Cho et al., 2000; Gong et al., 2012; Nguyen et al., 2012). The enzyme kinetic parameters were measured in a 50 mM sodium citrate buffer (pH 6.0) at 55°C for 30 min. From linear plots of the Michaelis-Menten equation such as Lineweaver-Burk or Hanes-Woolf plot using an Excel curve fitting program, the Km and Vmax of recombinant EG1 was calculated: In Lineweaver-Burk plot (R2 = 0.9998) Km and Vmax were 0.4% CMC and 144.9 U/mg, respectively. In Hanes-Woolf plot (R2 = 0.9997) they were 0.39% CMC and 143 U/mg, respectively.

Figure 5

Effect of the pH on the endoglucanase. The assay was performed at 55°C for 30 min in a 50 mM sodium citrate buffer (pH 3.0 to 6.0) and 50 mM sodium phosphate buffer (pH 6.0 to 8.0) with 0.7% carboxyl methyl-cellulose.

In conclusion, we have successfully cloned a novel endo-β-1,4-glucanase gene from cellulolytic rumen Actinomyces sp. KNG 40 bacterium into Excherichia coli, and analyzed nucleotide sequences and the enzymatic properties of the cloned endoglucanase. The cloned endoglucanase is more thermostable than enzymes produced by other rumen bacteria, and has powerful signal sequences for secretion of the enzyme into culture medium. Therefore, this recombinant endoglucanase may be a good candidate to be used in livestock feed as an additive to increase the digestibility of feedstuff for non-ruminant animal, and in the other industry.

ACKNOWLEDGMENTS

This work was financially supported by Priority Research Centers Program (No. 2009-0093813 to K. K. Cho) and by Basic Science Research Program (No. NRF-2013R1A1A2011997 to S. C. Kim) through the National Research Foundation of Korea (NRF) funded by the Ministry of Education, Science and Technology.

Notes

CONFLICT OF INTEREST

We certify that there is no conflict of interest with any financial organization regarding the material discussed in the manuscript.

References

Areej A, Altenaiji EM, Yousef LF. 2014;Fungal cellulases from mangrove forests — A short review. J Biochem Tech 5:765–774.
Baird SD, Johnson DA, Seligy VL. 1990;Molecular cloning, expression, and characterization of endo-beta-1,4-glucanase genes from Bacillus polymyxa and Bacillus circulans. J Bacteriol 172:1576–1586.
Bedford MR, Partridge GG. 2001. Enzymes in Farm Animal Nutrition CABI publishing. Wallingford, Xofrodshire, UK: p. 38.
Bradford MM. 1976;A rapid and sensitive method for the quantification of microgram quantities of protein utilizing the principle of protein dye binding. Anal Biochem 72:248–254.
Chang L, Ding M, Bao L, Chen Y, Zhou J, Lu H. 2011;Characterization of a bifunctional xylanase/endoglucanase from yak rumen microorganisms. Appl Microbiol Biotechnol 90:1933–1942.
Clarke AJ. 1997. Biodegradation of Cellulose: Enzymology and Biotechnology A Technomic Publishing Company Book. Lancaster, PA, USA: p. 43.
Cho KK, Kim SC, Woo JJ, Bok JD, Choi YJ. 2000;Molecular cloning and expression of a novel family A endoglucanase gene from Fibrobacter succinogenes S85 in Escherichia coli. Enzyme Microb Technol 27:475–481.
Coughlan MP. 1985;The properties of fungal and bacterial cellulases with comment on their production and application. Biotechnol Genet Eng Rev 3:39–110.
Culleton H, McKie VA, de Vries RP. 2014;Overexpression, purification and characterisation of homologous α-L-arabinofuranosidase and endo-1,4-β-D-glucanase in Aspergillus vadensis. J Ind Microbiol Biotechnol 41:1697–1708.
Forsberg CW, Gong J, Malburg LMJ, Zhu H, Iyo A, Cheng KJ, Krell PJ, Phillips JP. 1993. In : Preceedings of MIE Bioforum 93: Genetics, Biochemistry and Ecology of Lignocellulose Degradation. Toba, Japan. p. 125–136.
Gao D, Luan Y, Wang Q, Liang Q, Qi Q. 2015;Construction of cellulase-utilizing Escherichia coli based on a secretable cellulase. Microb Cell Fact 14:159–167.
Gilkes NR, Henrissat B, Kildrun DG, Miller RC, Warren RAJ. 1991;Domains in microbial β-1, 4-glycanases: Sequence conservation, function, and enzyme families. Microbiol Mol Biol Rev 55:303–315.
Gong X, Gruninger RJ, Qi M, Paterson L, Forster RJ, Teather RM, McAllister TA. 2012;Cloning and identification of novel hydrolase genes from a dairy cow rumen metagenomic library and characterization of a cellulase gene. BMC Res Notes 5:566–576.
Kuhad RC, Gupta R, Singh A. 2011;Microbial cellulases and their industrial applications. Enzyme Res Article ID 280696.
Laemmli UK. 1970;Cleavage of structural proteins during the assembly of the head of bacteriophage T4. Nature 227:680–685.
Lee DS, Pack MY. 1988;Use of Bacilli for overproduction of exocellular endo-beta-1,4-glucanase encoded by cloned gene. Enzyme Microb Technol 9:594–597.
Lemaire M, Beguin P. 1993;Nucleotide sequence of the celG gene of Clostridium thermocellum and characterization of its product, endoglucanase CelG. J Bacteriol 175:3353–3360.
Mackay RM, Lo A, Willick G, Zuker M, Baird S, Dove M, Moranelli F, Seligy V. 1986;Structure of a Bacillus subtilis endo-beta-1, 4-glucanase gene. Nucl Acids Res 14:9159–9170.
Malburg LM Jr, Forsberg CW. 1993;Fibrobacter succinogenes prossesses at least nine distinct glucanase genes. Can J Microbiol 39:882–891.
Min HK, Choi YJ, Ha JK, Cho KK, Kwon YM, Chang YH, Lee SS. 1994a;Isolation and identification of anaerobic rumen bacterium, Actinomyces sp. 40 and enzymatic properties of β-1,4-glucanase. Asian Australas J Anim Sci 7:373–382.
Min HK, Choi YJ, Cho KK, Ha JK, Woo JH. 1994b;Cloning of the endoglucanase gene from Actinomyces sp. 40 in Escherichia coli and some properties of the gene products. J Microbiol Biotechnol 4:102–107.
Mittendorf V, Thomson JA. 1993;Cloning of an endo-(1o>4)-betaglucanase gene, cel A, from the rumen bacterium Clostridium sp. (‘C.longisporum’) and characterization of its product. CelA, in Escherichia coli. J Gen Microbiol 139:3233–3242.
Miyatake M, Imada K. 1997;A gene encoding endo-1,4-beta-glucanase from Bacillus sp. 22–28. Biosci Biotechnol Biochem 61:362–364.
Nguyen NH, Maruset L, Uengwetwanit T, Mhuantong W, Harnpicharnchai P, Champreda V, Tanapongpipat S, Jirajaroenrat K, Rakshit SK, Eurwilaichitr L, Pongpattanakitshote S. 2012;Identification and characterization of a cellulase-encoding gene from the buffalo rumen metagenomic library. Biosci Biotechnol Biochem 76:1075–1084.
Ohara H, Noguchi J, Karita S, Kimura T, Sakka K, Ohmiya K. 2000;Sequence of egV and properties of EgV, a Ruminococcus albus endoglucanase containing a dockerin domain. Biosci Biotechnol Biochem 64:80–88.
Park KM, Shin HT, Kang KH. 1993;Isolation and identification of rumen bacteria from Korean native goat. I. Isolation and identification of Gram positive bacteria. Kor J Dairy Sci 15:165–177.
Perlman D, Halvorson HO. 1983;A putative signal peptidase recognition site and sequence in eukaryotic and prokaryotic signal peptides. J Mol Biol 167:391–409.
Poole DM, Hazlewood GP, Laurie JI, Barker PJ, Gilbert HJ. 1990;Nucleotide sequence of the Ruminococcus albus SY3 endoglucanase genes cel A and cel B. Mol Gen Genet 223:217–223.
Rashamuse KJ, Visser DF, Hennessy F, Kemp J, Rouxvan der Merwe MP, Badenhorst J, Ronneburg T, Francis-Pope R, Brady D. 2013;Characterisation of two bifunctional cellulase-xylanase enzymes isolated from a bovine rumen metagenome library. Curr Microbiol 66:145–151.
Sahu NP, Kamra DN, Paul SS. 2004;Effect of cellulose degrading bacteria isolated from wild and domestic ruminants on in vitro dry matter digestibility of feed and enzyme production. Asian Australas J Anim Sci 17:199–202.
Saito H, Miura K. 1963;Preparation of transforming deoxyribonucleic acid by phenol treatment. Biochim Biophys Acta. Specialized Section on Nucleic Acids and Related Subjects 72:619–629.
Sambrook J, Fritsch EF, Maniatis T. 1989. Molecular cloning: A laboratory manual 2nd Edth ed. Cold Spring Harbour Laboratory Press. Cold Spring Harbor, NY, USA:
Sanger R, Niclien S, Coulson AR. 1997;DNA sequencing with chain terminating inhibitors. Proc Natl Acad Sci 74:5463–5467.
Seo JK, Park TS, Kwon IH, Piao MY, Lee CH, Ha JK. 2013;Characterization of cellulolytic and xylanolytic enzymes of Bacillus licheniformis JK7 isolated from the rumen of a native Korean goat. Asian Australas J Anim Sci 26:50–58.
Shine J, Dalgano L. 1975;Determinant of cistron specificity in bacterial ribosomes. Naure 254:34–38.
Somogyi M. 1952;Notes on sugar determination. J Biol Chem 195:19–23.
Teather RM, Wood PJ. 1982;Use of Congo red – polysaccharide interactions in enumeration and characterization of celluloytic bacteria from the bovine rumen. Appl Environ Microbiol 43:777–780.
Von Heijne G. 1985;Signal sequences: The limits of variation. J Mol Biol 184:99–105.
Yan S, Wu G. 2014;Signal peptide of cellulase. Appl Microbiol Biotechnol 98:5329–5362.
Yuan SF, Wu TH, Lee HL, Hsieh HY, Lin WL, Yang B, Chang CK, Li Q, Gao J, Huang CH, Ho MC, Guo RT, Liang PH. 2015;Biochemical characterization and structural analysis of a bifunctional cellulase/xylanase from Clostridium thermocellum. J Biol Chem 290:5739–5748.

Article information Continued

Figure 1

Mapping and subcloning of the cloned endo-β-1,4-glucanase gene (pDS1).

Figure 2

SDS-PAGE of EG1. The gel was stained with Coomassie Blue R250. Endoglucanase (EG1) was identified using an MUC zymogram assay (data not shown). M, Protein molecular markers; lane 1 (10 μL) and lane 2 (2 μL) from fraction E1 and lane 3 (10 μL) and lane 4 (2 μL) from fraction E2 of the microcrystalline cellulose column eluent. SDS-PAGE, sodium dodecyl sulfate-polyacrylamide gel electrophoresis.

Figure 3

Nucleotide sequence of the 2,641 bp Sal I/Pst I restriction fragment of pDS3. The putative promoter sequence and ribosome-binding site are underlined. The deduced amino acid sequence for the endoglucanase is shown under the nucleotide sequence. Two amino terminal sequences determined for the recombinant endoglucanase are underlined. The Ser- and Thr-rich linker region is shown in the box.

Figure 4

Temperature-activity profile of the endoglucanase. The assay was performed for 30 min in a 50 mM sodium citrate buffer (pH 6.0) with 0.7% carboxyl methyl-cellulose.

Figure 5

Effect of the pH on the endoglucanase. The assay was performed at 55°C for 30 min in a 50 mM sodium citrate buffer (pH 3.0 to 6.0) and 50 mM sodium phosphate buffer (pH 6.0 to 8.0) with 0.7% carboxyl methyl-cellulose.

Table 1

Comparison of the amino acid sequences of the endoglucanase in this study with those various family 5 endoglucanases1

Protein Species Family Identity (%) Positivity (%) GenBank No.
Endoglucanase Fibrobacter succinogenes 5 67 80 U94826
Clostridium saccharobutylicum 5 43 59 P15704
Bacillus subtilis DLG 5 40 57 A26874
Bacillus amyloliquefaciens 5 41 58 AF363635
Ruminococcus albus 5 42 61 AB016777
Clostridium acetobutylicum 5 37 55 AE007585
1

The comparison of the amino acid sequences was performed with the NCBI’s BLAST program.

Table 2

Localization of endo-β-1,4-glucanase activity (in %) in Actinomyces sp. Korean native goat 40 and Escherichia coli (E. coli) DH5α

Host Fraction

Extracelluar Periplasmic Cytoplasmic Cell-bound Total activity
Actinomyces 67.7 11.3 10.5 10.5 100
E. coli 39.8 18.7 31.8 9.6 100

Table 3

Substrate specificity of endoglucanase from Escherichia coli DH5α harboring pDS3

Substrate Relative activity (%)
Carboxymethyl cellulose1 100
Xylan1 6.1
Avicell1 8.1
Cellobiose2 26
1

Enzyme activity was measured as the amount of reducing sugars released.

2

Enzyme activity was calculated from the amount of glucose released and divided by two.