Prediction of Digestible and Metabolizable Energy Content and Standardized Ileal Amino Acid Digestibility in Wheat Shorts and Red Dog for Growing Pigs

Article information

Asian-Australas J Anim Sci. 2012;25(12):1748-1758
*Corresponding Author: D. F. Li. Tel: +8610-6273-3588, Fax: +8610-6273-3688, E-mail: defali@public2.bta.net.cn
Ministry of Agriculture Feed Industry Centre, State Key Laboratory of Animal Nutrition, China Agricultural University, Beijing 100193, China
Received 2012 May 29; Accepted 2012 August 11; Revised 2012 August 28.

Abstract

Two experiments were conducted to evaluate the effects of chemical composition of wheat shorts and red dog on energy and amino acid digestibility in growing pigs and to establish prediction models to estimate their digestible (DE) and metabolizable (ME) energy content and as well as their standardized ileal digestible (SID) amino acid content. For Exp. 1, sixteen diets were fed to thirty-two growing pigs according to a completely randomized design during three successive periods. The basal diet was based on corn and soybean meal while the other fifteen diets contained 28.8% wheat shorts (N = 7) or red dog (N = 8), added at the expense of corn and soybean meal. Over the three periods, each diet was fed to six pigs with each diet being fed to two pigs during each period. The apparent total tract digestibility (ATTD) of energy in wheat shorts and red dog averaged 75.1 and 87.9%. The DE values of wheat shorts and red dog averaged 13.8 MJ/kg (range 13.1 to 15.0 MJ/kg) and 15.1 MJ/kg (range 13.3 to 16.6 MJ/kg) of dry matter, respectively. For Exp. 2, twelve growing pigs were allotted to two 6×6 Latin Square Designs with six periods. Ten of the diets were formulated based on 60% wheat shorts or red dog and the remaining two diets were nitrogen-free diets based on cornstarch and sucrose. Chromic oxide (0.3%) was used as an indigestible marker in all diets. There were no differences (p>0.05) in SID values for the amino acids in wheat shorts and red dog except for lysine and methionine. Apparent ileal digestibility (AID) and SID values for lysine in different sources of wheat shorts or red dog, which averaged 78.1 and 87.8%, showed more variation than either methionine or tryptophan. A stepwise regression was performed to establish DE, ME and amino acid digestibility prediction models. Data indicated that fiber content and amino acid concentrations were good indicators to predict energy values and amino acid digestibility, respectively. The present study confirms the large variation in the energy content and amino acid digestibility in wheat shorts and red dog, and describes the factors that influence this variation and presents equations based on chemical composition that could probably be used to predict the DE and ME values as well as the amino acid digestibility of wheat shorts and red dog.

INTRODUCTION

Wheat shorts and red dog are by-products of the wheat milling industry produced when wheat is processed into flour for human consumption and are often used as feed ingredients in the commercial feed industry (Blasi et al., 1998). These two wheat milling by-products both consist of fine particles of wheat bran, wheat germ, wheat flour, and the offal from the “tail of the mill” (AAFCO, 1996). However, the different combination and concentrations of different fractions among these by-products can lead to the variability of the chemical compositions of the end products.

There is growing demand for wheat shorts and red dog as an ingredient in swine diet formulation (Slominski et al., 2004). The inclusion of wheat shorts has been recommended at levels up to 30% of the diet (Holden and Zimmerman, 1991) as they provide a good source of energy, amino acids, and phosphorus for growing-finishing pigs (Erickson et al., 1985). However, a problem associated with the use of wheat shorts and red dog in diets for growing pigs is their lack of uniformity due to variable proportions of endosperm and bran particles (Huang et al., 1999). The nutrient content of wheat shorts and red dog depends on the physical properties of the original wheat used to produce them, the milling operation, and the end products desired (Blasi et al., 1998).

Few experiments have been conducted to evaluate the nutritional value of wheat milling by-products for pigs (Sauer et al., 1977; Erickson et al., 1985; Huang et al., 1999; 2001). Savant et al. (2004) recommended using chemical composition to predict the energy values of wheat milling by-products. Subsequently, Wan et al. (2009) developed models to predict energy values in wheat milling by-products (wheat bran, wheat middlings, wheat shorts and red dog) when fed to ducks. However, similar experiments have not been conducted with swine. Therefore, this study was conducted to measure the chemical composition of wheat shorts and red dog and determine their energy and amino acid digestibility using growing pigs. These values were then utilized to establish prediction models to estimate the energy content and amino acid digestibility of samples of wheat shorts and red dog.

MATERIALS AND METHODS

General

The Institutional Animal Care and Use Committee at China Agricultural University (Beijing, China) reviewed and approved the protocols used in the study. Seven samples of wheat shorts and 8 samples of red dog were collected from 10 provinces in China involving 15 separate wheat flour mills. Samples were taken, ground through a 1-mm screen, and then stored for further analysis. The chemical composition and source of the wheat shorts and red dog are shown in Table 1.

Chemical composition of fifteen samples of wheat shorts and red dog used in experiment 1 (% DM)1

Experimental design

Exp. 1 was conducted to determine the energy values of wheat shorts and red dog. Previous studies have recommended dietary inclusion levels of 20 to 40% wheat milling by-products in swine diets (Cromwell et al., 2000; Le Goff and Noblet, 2001). Therefore, a preliminary experiment was conducted using 19.2, 28.8, or 38.4% wheat shorts or red dog in the diet to monitor pig performance and the results of this experiment indicated that the optimal inclusion rate was 28.8% (data are not shown). Therefore, this inclusion level was chosen for use in Exp. 1.

In Exp. 1, sixteen diets were fed to thirty-two crossbred (Duroc×Landrace×Yorkshire) barrows (initial BW, 35.8±3.2 kg) according to a completely randomized design. The basal diet was based on corn and soybean meal while the other fifteen diets contained 28.8% wheat shorts or red dog added at the expense of corn and soybean meal. The basal diet with no addition of wheat by-products was formulated to allow for calculation of the DE and ME content of the fifteen samples of wheat shorts or red dog using the difference method (Adeola, 2001). All ingredients were ground through a 2.5-mm screen (hammer mill). The ingredient composition of the diets used in the study is presented in Table 2.

Ingredient of composition of experimental diets (Exp. 1, % as fed)

The thirty-two crossbred pigs were individually housed in stainless steel metabolism cages (1.4×0.45×0.6 m3). The 32 pigs were assigned to the sixteen treatments in three successive replicates of 16 pigs (2 pigs per treatment). Over the three periods, each diet was fed to six pigs with each diet being fed to two pigs during each period. Each period lasted 12 d comprised of a 7 d adaptation period followed by a 5 d total collection of feces and urine.

Pigs were weighed at the beginning of each period. The diets were provided at a rate of 4% of the average BW determined at the initiation of each adaptation period. The daily feed allowance was divided into two equal meals fed at 08:00 and 17:00 h. Water was freely available from a low-pressure drinking nipple. The diets were all provided in mash form.

Before the initiation of Exp. 2, an experiment was conducted to determine what percentage of wheat shorts and red dog the pigs would tolerate in their diets. There were some comparative studies (Fan and Sauer, 1995a, b) in which the effects of direct and difference methods on AID values were compared, and no major impact on the determinations of AID values were found. Also, no differences were also observed between SID values in the study of Fan and Sauer (1995a) and Eklund (2008), either determined according to the direct and regression analysis method. To decrease the risk of error and interactions by difference method, wheat shorts or red dog were fed to pigs directly as the sole protein source in the diet and 60% percentage was the level chosen for future use (data are not shown).

In Exp. 2, ten samples of wheat shorts or red dog were chosen to determine the ileal digestibility of amino acids according to the maximum variance of amino acids content distribution in samples. Ten diets were formulated consisting of 60.0% wheat shorts or red dog, 24.30% cornstarch, 10.0% sucrose, 2.0% soybean oil and 3.7% vitamins and minerals added to meet or exceed the estimated nutrient requirements for growing pigs with the exception of amino acids (NRC, 1998). A nitrogen-free diet was used to determine the basal ileal endogenous nitrogen losses. Chromic oxide (0.3%) was added into all of the diets as the inert marker. Potassium carbonate and magnesium oxide were included in the nitrogen-free diet to meet the pig’s mineral requirements. Soybean oil was included at a level 3% to reduce dustiness and increase the energy density of the diets.

For Exp. 2, twelve crossbred (Duroc×Landrace×Yorkshire) barrows (initial BW, 35.1±2.5 kg) were fitted with a simple T-cannula at the distal ileum using procedures described by Stein et al. (1998) and allotted to two 6×6 Latin square design with 6 periods and 12 diets. During a 14-d period, a nutritionally balanced commercial diet was provided to the pigs. Each experimental period lasted 9 d. Following a 5-d adaptation period, digesta was collected for a 2-d experimental period (08:00 to 16:00). After each collection period, the pigs were fed a commercial diet for two days to recover.

For Exp. 1, after an adaptation period of 7 d, a total collection of feces and urine was conducted for five successive days following the methods described by Song et al. (2003). Feed refusals and spillage were collected daily and analyzed for DM content. Feces were collected immediately as feces appeared in the metabolism crates and placed in plastic bags to be stored at −20°C. Urine was collected in a bucket placed under the metabolic crate. The bucket contained 10 ml of 6 N HCl for every 1,000 ml of urine. Each day, the total urine volume was measured and a 10% aliquot was filtered through gauze and 50 ml of the mixed urine samples were transferred into a screw-capped tube and stored immediately at −20°C until needed for analysis. At the end of the collection period, feces were thawed, pooled by pig within period, homogenized, sub-sampled, dried 72 h in a 65°C drying oven and ground through a 1-mm screen.

For Exp. 2, Digesta was collected in plastic bags attached to the simple T-cannula until the bag was full and stored in a −20°C freezer immediately after each collection. Ileal digesta samples were thawed, mixed within animal and diet, and a sub-sample was taken. Digesta samples were lyophilized in a vacuum-freeze dryer (Tofflon Freezing Drying Systems, Minhang District, Shanghai, China) and ground through a 1-mm screen for further chemical analysis.

Chemical analyses

DM, ether extract (EE), CP (Nx6.25), ash, CF, NDF, ADF, Ca and P content in diets and wheat shorts and red dog were analyzed according to the procedures of the Association of Official Analytical Chemists (AOAC, 2000). The gross energy (GE) of feces, diets and wheat shorts and red dog samples were measured using an automatic adiabatic oxygen bomb calorimeter (Parr 6300 Calorimeter, Moline, IL). The gross energy (GE) of urine was injected 4 ml sample into 2 filter papers in a special crucible, and dried 8 h in 65°C drying oven to determine the energy. Wheat shorts and red dog samples were hydrolyzed with 11 N sulfuric acid at 128°C for 3 h and an Ion Chromatograph (Dionex ICS-3000, Sunnyvale, CA, USA) was then used to analyze xylans. Starch content was determined after converting starch to glucose using an enzyme assay kit (Megazym International Ireland, Wicklow, Ireland). Wheat shorts and red dog, diets, digesta were hydrolyzed with 6 N HCl at 110°C for 24 h and analyzed for 15 amino acids using an Amino Acid Analyzer (Hitachi L-8900, Tokyo, Japan). Methionine and cystine were determined as methionine sulfone and cysteic acid after cold performic acid oxidation overnight and hydrolyzing with 7.5 N HCl at 110°C for 24 h using an Amino Acid Analyzer (Hitachi L-8800, Tokyo, Japan). Tryptophan was determined after LiOH hydrolysis for 22 h at 110°C using HPLC (Agilent 1200 Series, Santa Clara, CA, USA). The chromium concentration of diets and ileal digesta samples were determined after nitric acid-perchloric acid wet ash sample preparation using Polarized Zeeman Atomic Absorption Spectrometer (Hitachi Z2000, Tokyo, Japan).

Calculations and statistical analyses

In Exp. 1, the DE and ME values contributed by each samples were calculated according to difference method (Adeola, 2001) by subtracting the DE and ME values contributed by the basal energy contributing ingredients.

In Exp. 2, the AID for the amino acids in the diets containing wheat shorts and red dog were calculated using the equations described by Stein et al. (2007):

AID=(1(AAd/AAf)×(Crf/Crd))×100%

where AAd is the concentration of amino acids in the ileal digesta (g/kg of DM), AAf is the concentration of amino acids in the diets (g/kg of DM), Crf represents chromium concentration in the diet (g/kg of DM), and Crd represents in the digesta (g/kg of DM). The AID for CP was also calculated by using this equation where amino acids are replaced by the concentration of the CP in the digesta and diets.

The basal endogenous loss of each amino acid (IAAend, g/kg of DMI) at the distal ileum was determined based on the outflow obtained when pigs were fed the N-free diet using the equation of Stein et al. (2007):

IAAend=(AAd×(Crf/Crd))×100%

where AAd is the concentration of each amino acid in the ileal digesta collected from pigs fed the N-free diet. The endogenous outflow of CP was determined using the same equation where AAd is replaced by the concentration of the CP in the digesta.

By correcting the AID of each amino acid that was calculated for each sample for the IAAend of each amino acid, the SID of each amino acid was calculated using the equation of Stein et al. (2007):

SID=(AID+(IAAend/AAdiet)×100%)

Statistical analysis

The linear equations for predicting the DE, ME and ileal amino acid digestibility of samples from chemical composition were obtained using the stepwise regression procedure with SAS (SAS Inst. Inc., Cary, NC). The sources of wheat shorts and red dog in experiments were compared using a general linear model with wheat shorts and red dog, pig, and period as the main effects. If significant differences were found, the Student Newman Keul’s test was used to test the significance of differences between means. The contrast option of SAS was used to compare energy values and amino acid digestibility of wheat shorts and red dog. The level of significance adopted was 1% (p<0.01). The equations with the smallest residual standard deviation (RSD) are presented in the results.

RESULTS

Chemical composition of wheat shorts and red dog

There were seventeen samples collected in total, fifteen samples for Exp. 1 and ten samples for Exp. 2, in such, eight samples were used in both Exp. 1 and 2.

The collected wheat shorts and red dog samples varied widely in chemical composition (Tables 1 and 6). From these two tables, we could see that, NDF concentration in wheat shorts ranged from 21.21 to 30.38% (mean 26.12%) of DM and red dog from 6.18 to 20.79% (mean 13.33%) of DM, while values of ADF in wheat shorts ranged from 3.77 to 8.66% (mean 6.00%) of DM and red dog from 1.40 to 5. 17% (mean 2.76%) of DM, showing more variation than most other non-fiber nutrients.

Chemical analysis of ten samples of wheat shorts and red dog used in Exp. 2 (%, DM)1

As to amino acid content in ten samples of wheat shorts and red dog, the values of lysine ranged from 0.31 to 0.66%, with a mean value of 0.49%. Concentrations of methionine ranged from 0.22 to 0.32% and averaged 0.27%. Threonine and tryptophan concentrations ranged from 0.34 to 0.49% and from 0.14 to 0.21% and averaged 0.53 and 0.18%, respectively.

Energy concentration and energy digestibility of wheat shorts and red dog

Energy concentration and ATTD of GE of the wheat shorts and red dog are shown in Table 4. The DE (mean 13.80 MJ/kg) and ME (mean 13.20 MJ/kg) of wheat shorts ranged from 13.06 to 15.01 MJ/kg and 12.48 to 14.82 MJ/kg of DM, respectively. The DE and ME of red dog ranged from 13.31 to 15.96 MJ/kg and 12.56 to 15.08 MJ/kg of DM, respectively. The difference among DE in wheat shorts was 1.95 MJ/kg and in red dog was 2.65 MJ/kg of DM. The ratio of DE to ME calculated from 15 measured samples ranged from 93.13 to 98.72%, with a mean value of 95.44%.

Energy concentration and apparent total digestibility of energy of the wheat shorts and red dog for Exp. 11

Prediction of energy values of wheat shorts and red dog

DE and ME values can be predicted from the nutrients concentration of the chemical composition of wheat shorts and red dog. Some equations based on a single chemical characteristic showed a highly linear correlation. The NDF (g/kg of DM) was the best single predictor (R2 = 0.84, p<0.01) in DE (MJ/kg of DM) values of wheat shorts and red dog, followed by starch (R2 = 0.77, p<0.01), CF (R2 = 0.75, p<0.01), ash (R2 = 0.75, p<0.01), and total xylans (R2 = 0.72, p<0.01) concentrations. Multiple linear regression analyses were conducted to develop prediction equations for DE and ME values of wheat shorts and red dog based on the results of step-wise regression analysis (Table 5). The models were further improved by inclusion of ADF content in the DE model. The best model for prediction of DE was obtained: DE = −0.18×NDF+0.20×ADF+16.97 (R2 = 0.87; p<0.01). In addition, more indicators were included in the ME equations, such as xylans, CP and P. Moreover, DE and ME values were highly correlated (ME = 0.92×DE+0.44; R2 = 0.96; p<0.01).

Prediction of energy value (MJ/kg of DM) from chemical composition (% of DM) in wheat shorts and red dog

Ileal digestibility of crude protein and amino acids (Exp. 2)

AID of nutrients values are shown in Table 9. Among the ten samples of wheat shorts and red dog, there was significant difference (p<0.01) in AID of DM, CP and most amino acids except for isoleucine, methionine, phenylalanine, and tryptophan. The AID of DM ranged from 76.15 to 87.06%, with a mean value of 80.91%.

Apparent ileal digestibility (%) of dry matter, crude protein and amino acids in wheat shorts and red dog tested in Exp. 2 (% as fed)

The AID of CP in wheat shorts ranged from 76.58% (sample SC) to 80.33% (sample GS), with a mean value of 78.80%. Otherwise, the values of red dog ranged from 74.83 (sample HLJ) to 77.53% (sample LN) and averaged 76.50%. The AID of lysine ranged from 76.31 to 86.28% in wheat shorts and 65.66 to 83.52% in red dog. In wheat shorts and red dog, the AID of methionine (85.84 to 90.53%) and tryptophan (77.42 to 81.49%) showed less variation than threonine (65.50 to 78.07%). The SID values of CP and amino acids presented (Table 10) were high among samples. The methionine (mean 92.88%) for SID was higher than tryptophan (mean 89.32%), threonine (mean 87.89%) and lysine (mean 87.78%).

Standardized ileal digestibility (%) of crude protein and amino acids in wheat shorts and red dog tested in Exp. 2 (% as fed)1

Prediction of nitrogen and amino acids digestibility in wheat shorts and red dog

Regression equations (Table 11) among N, the AID and SID for amino acids with chemical characteristics (% of DM) of wheat shorts and red dog indicated that variable N, amino acids and fiber content in samples mainly predicted the digestibility.

Prediction of amino acid digestibility (% as fed) from chemical composition (% of DM) in wheat shorts and red dog

The equations obtained followed a stepwise regression procedure showing that N digestibility could be evaluated from CP values. In addition, the best predictor for AID of lysine was the concentration of lysine in CP (Table 11) according to a linear stepwise regression (R2 = 0.83, p<0.01). However, the SID of lysine had a relatively poor relationship with the lysine concentration in CP (R2 = 0.65, p<0.01). Moreover, the SID of threonine and methionine showed poorer models than SID of lysine.

DISCUSSION

Definitions and classifications of wheat milling by-products vary widely among the NRC (1998), Chinese Feed Database (2005) and Sauvant et al. (2004). The values of CP, NDF and ADF in wheat shorts and red dog (NRC, 1998) were within the range obtained in our study, but mean values of Ca, P, EE for the samples obtained in the current study were slightly lower than NRC (1998) values. The amino acids values in wheat shorts and red dog were also slightly lower than previously reported data (NRC, 1988), with the exception of methionine, tryptophan and valine. It could be concluded that the wheat shorts and red dog obtained have more fiber in aleurone and pericarp leading to the higher amino acids content (Cromwell et al., 2000; Sauvant et al., 2004; Chinese Feed Database, 2005). Similarly the relationship of NDF with lysine content in fourteen sources of wheat middlings were also positively correlated with Cromwell’s (2000) study (R2 = 0.72). Cromwell et al. (2000) showed a similar relationship of CP concentration with amino acids concentrations in wheat middlings. In all, wheat pericarp and aleurone, as well as wheat functional proteins (albumins and globulins), have higher amino acids concentrations than endosperm except for phenylalanine (Jondreville et al., 2000). Besides tryptophan, other amino acids’ contents were highly correlated with CP in wheat shorts and red dog samples (R2>0.80, Data are not shown).

Wheat shorts and red dog in the NRC (1998) of DE values were 14.19 and 14.93 MJ/kg of DM and ME values were 13.40 and 13.90 MJ/kg of DM, respectively. The average DE for the wheat shorts and red dog determined in the present study were 13.79 and 15.06 MJ/kg of DM, and ME averaged 13.24 and 14.30 MJ/kg of DM, respectively. Therefore, the values of DE and ME obtained in the current study agreed with the data published by NRC (1998). Likewise, Patience et al. (1977) reported that several samples of wheat shorts had a value from 12.13 to 14.39 MJ/kg DE of DM. Batterham et al. (1980) reported that DE values of eight wheat by-products (mainly wheat middlings) contained from 10.90 to 14.10 MJ/kg of DM. Wheat milling by-products like wheat shorts and middlings generally had a higher fiber content compared to the parent grains, were therefore not as well digested by growing pigs, and have a lower energy density (Holden and Zimmerman, 1991). From the published nutritional values of wheat milling byproducts, it does not make much sense to compare the nutritional values of wheat milling by-products statically due to the large variability of compositions therefore dynamic comparisons and prediction models are more necessary and meaningful.

Few reporters previously published the amino acids digestibility of the wheat shorts and red dog, specifically regarding SID values. There were no differences between wheat shorts and red dog in amino acids for SID values in the study. This may be explained that in the study the NDF content in the diets had a mean value of 14.57% and can tolerate up to 16.80% NDF without a depression in ileal amino acids digestibility as reported by Li et al. (1994). That is to say the CP and amino acids content in the wheat shorts and red dog may play a more important role in amino acids digestibility.

The AID of amino acids in wheat shorts were generally higher than previously reported wheat shorts values (NRC, 1998; Huang et al., 1999), but similar to the values of the Chinese Feed Database (2005). Most amino acids for SID were rather high caused by higher endogenous losses excreted by small intestines. The endogenous losses caused by amino acids digested in the small intestine depended on the sequencing of enzymatic hydrolysis to each amino acid (Low, 1980) and fibers or anti-nutritional factors were fed (Stein et al., 2007). In addition, the values of AID and SID of amino acids in the study were within the range of wheat shorts and wheat feed flour values (Sauvant et al., 2004). Among the ten samples of wheat shorts and red dog, differences (p<0.05) in the SID for CP and amino acids were observed. The SID were higher than AID values because wheat shorts and red dog diets containing relatively lower CP and amino acids concentrations usually had lower AID due to endogenous losses contributing relatively more to the ileal output of amino acids (Fan et al., 1994). Also, the low ileal digestibility of lysine compared to other amino acids probably results lysine being highly concentrated in the fibrous part of the wheat grains, as well as in the great decrease in digestibility in wheat shorts and red dog (Jondreville et al., 2000).

Considerable variation exists in the DE values in wheat milling by-products (Batterham et al., 1980) and if energy values were not accurately predicted, it would result in great differences between actual and expected diet DE and ME content. However, limited published information was available on the complete chemical composition correlated with the DE and ME of wheat shorts and red dog. Correlation coefficients and prediction equations with chemical compositions clearly indicated that fibrous components predominantly determined the energy values. In the ME stepwise regression equations, NDF, xylans, CP, and P came into the model successively. As expected, the higher dietary fiber content, the lower the digestibility of energy values. Several researchers have been able to accurately estimate the energy level in wheat milling byproducts (Batterham et al., 1980; Wan et al., 2009) with NDF as the primary predictor variable. NDF, a total measurement of cellulose, hemi-cellulose and lignin, was the most significant factor affecting the DE and ME variation. Simple regression increased 1% in NDF, leading to a 0.74% (0.13 MJ) decrease in DE (Eq. 1) and a decrease of 0.66% (0.11 MJ) (Eq. 7) in ME values in wheat shorts and red dog (Table 5). In addition, Batterham’s (1980) equation predicting DE values of wheat by-products showed a similar result with a 1% increase in NDF leading to 0.66% decrease in DE values, slightly lower than the equation in this study. Compared with the data of correlation coefficients (Data are not shown) among DE of DM values of samples and NDF, ADF, ash, EE and GE were −0.92, −0.76, −0.86, −0.57 and 0.02 in the study, respectively. Interestingly, the coefficient of EE was negative with energy values in the study and similar results were found in other cereal grain feedstuff (unpublished data) in our lab. Sorghum showed the same result in Batterham’s study, and the reason for this was likely due to the negative relationship (R2 = 0.54, p<0.01) between starch and EE contents of the wheat shorts and red dog diets. This inverse relationship should result in the maintenance of a relatively high content of available energy in wheat shorts and red dog in despite of lower EE content, which may be explained that the energy contribution of EE in cereal grains are low and digestibility were lower than extracted EE and thus could nearly be ignored. Total xylans concentration was negatively correlated with DE content, which was a specific component of none starch polysaccharides and a more accurate measure of individual monomeric sugars (Kim et al., 2005). It has been reported that xylans are strongly correlated with energy values of wheat and by-products in many reports. The R2 reached 0.71 using xylans as a single indicator to predict the DE values, which was not superior to NDF as a predictor in the study. However, Zijlstra et al. (1999) reported the total xylans were superior for prediction of DE content of wheat over NDF in growing pigs. The contradictions might partly be explained by different producing areas and different wheat sources of wheat shorts and red dog in the study, and NDF containing minimal pectin content in by-products not in whole wheat might provide similar or better accuracy than the use of xylans that showed less variation in samples than NDF for prediction of DE content (Kim et al., 2005). From these equations, the result showed that crude fiber content was strongly correlated with ash, xylans, starch and detergent fiber in which these predictors showed a rather high R square and no indicators came into prediction models to increase the accuracy, therefore, no more multiple regression equations were founded.

When predicting N and amino acids digestibility with stepwise regression in SAS, only one variable entered to into the models in each of the equations. As previously reported by Jondreville et al. (2000), except for the indicator of the ratio of dietary fiber to the amino acid content, the nitrogen bound to NDF residue were also thought as relevant predictors for amino acid in true ileal digestibility of wheat milling by-products. The prediction equations proposed were more accurate and meaningful as they may represent the probable increase of both endogenous losses and the amount of undigested protein from wheat by-products. The accuracy of SID models were all poor than the AID as a single predictor such as fiber and amino acids after correcting the endogenous nitrogen and amino acids losses. As to lysine digestibility, the lysine concentration per unit of CP appeared as a quick and reliable indicator for prediction of lysine digestibility (Cozannet et al., 2010). The results of current experiment indicate that lysine concentration per unit of CP was positively correlated with AID and SID for lysine. However, dietary fiber concentrations relative to amino acid concentrations can not show a good predictive result in this study. For example, compared to lysine content in samples, because of its constant and low concentrations of methionine and tryptophan, the digestibility of these two amino acids did not have good relationships with some predictors, seeming to be influenced more by the combined actions of chemical composition.

CONCLUSION

In summary, DE and ME values among fifteen wheat shorts and red dog samples are widely ranged and are highly correlated with the cell wall carbohydrates. As to amino acids digestibility, wheat shorts and red dog varies among various sources, and lysine digestibilities have more variation than other amino acids and are more predictable. Further research is warranted to confirm the results of the current experiment and estimate more accurate prediction equations based on more systematic chemical composition.

Chemical composition of the control and the experimental diets for Exp. 1 (% DM)

Ingredient of composition of experimental diets in Exp. 2 (%, as-fed)

Analyzed composition of experimental diets used in Exp. 2 (% DM)

ACKNOWLEDGEMENT

This research was financially supported by the Special Public Sector Fund in Agriculture (200903006).

References

AAFCO. 1996. Official publication Assoc. Am. Feed Control Off. Inc.. St. Louis. MO, USA:
AOAC. 2000. Official methods of analysis 17th edth ed. Association of Official Analytical Chemists. Arlington, VA, USA:
Adeola O. 2001. Digestion and balance techniques in pigs. Swine Nutrition 2nd edth ed. In : Lewis DJ, Southern LL, eds. CRC Press. New York: p. 903–916.
Batterham ES, Lewis CE, Lowe RF, McMillan CJ. 1980;Digestible energy content of cereals and wheat by-products for growing-pigs. Anim Prod 31:259–271.
Blasi DA, Kuhl GL, Drouillard JS, Reed CR, Trigo-Stockli DM, Behnke KC, Fairchild FJ. 1998. Wheat middlings: Composition, feeding value, and storage guidelines. MF-2353 Kansas State University. Agricultural Experiment Station and Cooperative Extension Service, Manhattan, Kansas:
Chinese Feed Database. 2005. Tables of feed composition and nutritive values for pigs in China The Center of Chinese Feed Database Information; Beijing: http://www.chinafeeddata.org.cn. Accessed May 2007. (in Chinese).
Cozannet P, Primot Y, Gady C, Metayer JP, Callu P, Lessire M, Skiba F, Noblet J. 2010;Ileal digestibility of amino acids in wheat distillers dried grains with solubles for pigs. Anim Feed Sci Technol 158:177–186.
Cromwell GL, Cline TR, Crenshaw JD, Crenshaw TD, Easter RA, Ewan RC, Hamilton CR, Hill GM, Lewis AJ, Mahan DC, Nelssen JL, Pettigrew JE, Veum TL, Yen JT. 2000;Variability among sources and laboratories in analyses of wheat middlings. J Anim Sci 78:2652–2658.
Eklund M, Mosenthin R, Piepho H-P, Rademacher MR. 2008;Estimates of basal ileal endogenous losses of aminoa acids by regression analysis and determination of standardized ileal aminoa acid digestibilities from casein in newly weaned pigs. J Sci Food Agric 88:641–651.
Erickson JP, Miller ER, Ku PK, Collings GF, Black JR. 1985;Wheat middlings as a source of energy, aminoacids, phosphorus and pellet binding quality for swine diets. J Anim Sci 60:1012–1020.
Fan MZ, Sauer WC, Lien KA. 1994;Effect of dietary amino acid level on the determination of apparent ileal amino acid digestibility in pigs. J Anim Sci 72:2851–2859.
Fan MZ, Sauer WC. 1995a;Determination of apparent ileal amino acid digestibility in barley and canola meal for pigs with direct difference, regression methods. J Anim Sci 73:2364–2374.
Fan MZ, Sauer WC. 1995b;Determination of apparent ileal amino acid digestibility in peas for pigs with direct difference, regression methods. Livest Prod Sci 44:61–72.
Holden PJ, Zimmerman DR. 1991. Utilization of cereal grain by-products in feeding swine. Swine Nutrition In : Miller ER, Ullrey DE, Lewis AJ, eds. Butterworth. London: p. 585–593.
Huang SX, Sauer WC, Marty B. 2001;Ileal digestibilities of neutral detergent fiber, crude protein, and amino acids associated with neutral detergent fiber in wheat shorts for growing pigs. J Anim Sci 79:2388–2396.
Huang SX, Sauer WC, Marty B, Hardin RT. 1999;Amino acid digestibilities in different samples of wheat shorts for growing pigs. J Anim Sci 77:2469–2477.
Jondreville C, Broecke JVD, Grosjean F, Cauwenberghe SV, Gatel F. 2000;Ileal true digestibility of amino acids in wheat milling by-products for pigs. Ann Zootech 49:55–65.
Kim JC, Simmins PH, Mullan BP, Pluske JR. 2005;The digestible energy value of wheat for pigs, with special reference to the post-weaned animal [review]. Anim Feed Sci Technol 122:257–287.
Le Goff G, Noblet J. 2001;Comparative total tract digestibility of dietary energy and nutrients in growing pigs and adult sows. J Anim Sci 79:2418–2427.
Li S, Sauer WC, Hardin RT. 1994;Effect of dietary fibre level on amino acid digestibility in young pigs. Can J Anim Sci 74:327–333.
Low AG. 1980;Nutrient absorption in pigs. J Sci Food Agric 31:1087–1130.
NRC. 1998. Nutrient requirements of swine 10th rev edth ed. National Academy Press. Washington DC, USA:
Patience JF, Young LG, McMillan I. 1977;Utilization of wheat shorts in swine diets. J Anim Sci 45:1294–1301.
Sauer WC, Stothers SC, Parker RJ. 1977;Apparent and true availabilities of amino acids in wheat and milling by-products for growing pigs. Can J Anim Sci 57:775–784.
Sauvant D, Perez JM, Tran G. 2004. Tables of composition and nutritive value of feed materials. Pigs, Poultry, Cattle, Sheep, Goats, Rabbits, Horses, Fish INRA Editionsth ed. Versailles. France:
Slominski BA, Boros D, Campbell LD, Guenter W, Jones O. 2004;Wheat by-products in poultry nutrition. Part I. Chemical and nutritive composition of wheat screenings, bakery by-products and wheat mill run. Can J Anim Sci 84:421–428.
Song GL, Li DF, Piao XS, Chi F, Yang WJ. 2003;Apparent ileal digestibility of amino acids and the digestible and metabolizable energy content of high-oil corn varieties and its effects on growth performance of pigs. Arch Anim Nutr 57:297–306.
Stein HH, Seve B, Fuller MF, Moughan PJ, de Lange CF. 2007;Invited review: Amino acid bioavailability and digestibility in pig feed ingredients: Terminology and application. J Anim Sci 85:172–180.
Stein HH, Shipley CF, Easter RA. 1998;Technical note: A technique for inserting a T-cannula into the distal ileum of pregnant sows. J Anim Sci 76:1433–1436.
Wan HF, Chen W, Qi ZL, Peng P, Peng J. 2009;Prediction of true metabolizable energy from chemical composition of wheat milling by-products for ducks. Poult Sci 88:92–97.
Zijlstra RT, de Lange CFM, Patience JF. 1999;Nutritional value of wheat for growing pigs: Chemical composition and digestible energy content. Can J Anim Sci 79:187–194.

Article information Continued

Table 1

Chemical composition of fifteen samples of wheat shorts and red dog used in experiment 1 (% DM)1

Item (%) Wheat red dog
Mean CV2 Wheat shorts
Mean CV
HENa HENc HEBa LN SX HENd XJ JSb GS SC HENb HUB FJ HEBb JSa
CP 15.05 14.16 14.70 13.95 16.14 17.78 16.40 16.81 15.62  8.74 17.76 15.43 19.41 18.42 20.36 17.53 17.02 17.95  8.77
Ether extract  2.25  1.73  2.39  2.48  2.60  3.64  3.36  3.08  2.69 23.34  3.65  2.54  3.98  2.23  4.70  4.93  4.03  3.72 27.32
NDF  7.80  6.18  9.37 11.11 16.66 15.04 20.79 19.91 13.36 41.52 29.62 21.21 25.58 26.68 24.35 28.97 30.38 26.68 12.25
ADF  2.22  1.44  1.60  2.31  3.54  4.22  4.49  5.17  3.12 45.38  6.68  4.80  5.73  3.81  6.87  7.98  8.66  6.36 26.93
Starch 81.31 79.16 61.29 68.16 58.88 60.26 44.30 47.26 62.58 21.32 48.62 44.22 42.12 40.31 39.83 26.65 35.36 39.59 17.72
Crude fiber  1.33  1.70  1.98  2.55  2.92  3.16  4.34  4.64  2.83 42.27  4.91  5.04  5.12  6.75  6.89  7.23  7.66  6.23 18.70
Xylans  2.22  3.44  2.66  3.87  3.35  4.89  8.26  1.87  3.82 53.22 10.54  7.14 10.36  9.95  9.81  8.42  8.45  9.24 13.61
Ash  1.30  0.93  1.50  1.34  1.86  2.09  3.01  2.74  1.85 39.52  3.12  2.48  2.84  3.97  3.81  4.56  3.78  3.51 20.61
Calcium  0.03  0.02  0.03  0.02  0.06  0.03  0.09  0.07  0.04 59.78  0.08  0.06  0.07  0.06  0.07  0.08  0.08  0.07 12.60
Phosphorus  0.29  0.23  0.22  0.27  0.32  0.37  0.53  0.46  0.34 31.32  0.41  0.45  0.52  0.71  0.74  0.77  0.68  0.61 24.17
abcd

Samples from different flour mills in a province.

1

15 samples from 15 wheat flour mills in 10 provinces (HEN = He’nan, HEB = Hebei, LN = Liaoning, SX = Shanxi, XJ = Xinjiang, JS = Jiangsu, GS = Gansu, SC = Sichuan, FJ = Fujian, HUB = Hubei).

2

CV = Coefficient of variation.

Table 2

Ingredient of composition of experimental diets (Exp. 1, % as fed)

Ingredient (%) Basal diet Wheat shorts or red dog diets
Corn 71.52 50.06
Soybean meal 24.20 16.94
Wheat shorts or red dog - 28.80
L-lysine-HCl, 98%  0.28  0.20
Dicalcium phosphate  1.40  1.40
Calcium carbonate  0.90  0.90
Wheat rice stone1  0.80  0.80
Sodium chloride  0.40  0.40
Vitamin-mineral premix2  0.50  0.50
1

Used as carrier for L-lysine HCl and contained more than 70% silicon oxide and aluminium oxide, made by YiXian BeiQiaoTou Ore Company Limited, Hebei, China.

2

Provided the following per kilogram of diet: Mn, 50 mg as MnO; Fe, 125 mg as FeSO4·H2O; Zn, 125 mg as ZnO; Cu, 150 mg as CuSO4·5H2O; I, 50 mg as CaI2; Se, 0.48 mg as Na2SeO3, retinyl acetate, 4,500 IU; cholecalciferol, 1,350 IU; DL-α- tocopheryl acetate, 13.5 mg; menadione sodium bisulfite complex, 2.7 mg; niacin, 18 mg; vitamin B12, 27.6 μg; thiamine, 0.6 mg; pyridoxine, 0.9 mg; riboflavin, 1.8 mg; D-ca-pantothenate, 10.8 mg; nicotinic acid, 30.3 mg; choline chloride, 210 mg.

Table 3

Chemical composition of the control and the experimental diets for Exp. 1 (% DM)

Item (%) Basal diet Wheat red dog diets
Mean CV2 Wheat shorts diets
Mean CV
HENa HENc HEBa LN SX HENd XJ JSb GS SC HENb HUB FJ HEBb JSa
CP 19.39 18.59 19.61 18.75 17.32 19.51 18.29 19.85 19.87 18.97  4.73 20.74 18.69 19.96 24.23 22.34 19.61 20.60 20.88  8.90
EE  1.84  1.38  2.13  1.57  2.13  1.53  1.70  2.44  3.35  2.03 31.97  2.52  2.21  1.98  2.26  2.38  2.77  2.52  2.38 10.72
NDF 15.28 13.47 14.56 14.84 13.61 15.62 12.69 20.52 16.58 15.23 16.22 17.97 16.26 17.22 17.41 18.80 19.65 20.00 18.19  7.48
ADF  3.96  3.41  3.61  3.64  3.59  4.12  3.50  5.29  4.31  3.93 16.03  4.91  4.68  4.77  4.51  5.05  5.25  5.77  4.99  8.44
Ash  6.89  5.74  6.10  5.56  6.29  5.42  5.66  6.74  6.89  6.05  9.12  6.33  6.01  6.39  7.80  6.61  7.03  6.71  6.70  8.68
GE 17.90 18.00 18.68 17.87 17.52 17.90 17.78 20.07 17.98 18.23  4.46 17.95 17.62 17.84 21.46 18.14 17.81 18.12 18.42  7.34
abcd

Samples from different flour mills in a province.

1

15 samples from 15 wheat flour mills in 10 provinces (HEN = He’nan, HEB = Hebei, LN = Liaoning, SX = Shanxi, XJ = Xinjiang, JS = Jiangsu, GS = Gansu, SC = Sichuan, FJ = Fujian, HUB = Hubei).

2

CV = Coefficient of variation.

Table 4

Energy concentration and apparent total digestibility of energy of the wheat shorts and red dog for Exp. 11

Item Wheat red dog
Mean2 CV3 Wheat shorts
Mean CV p-value4
HENa HENc HEBa LN SX HENd XJ JSb GS SC HENb HUB FJ HEBb JSa Overall WS vs RD
DE (MJ/kg as-fed basis) 13.67 14.52 13.96 13.21 13.17 13.36 12.06 13.08 13.38  5.38 12.22 12.05 11.96 11.56 12.59 11.75 11.67 11.97  2.97 <0.01  0.02
ME (MJ/kg as-fed basis) 13.05 13.70 13.20 12.30 12.70 12.62 11.69 12.91 12.77  4.74 11.81 11.42 11.48 11.06 12.11 11.08 10.97 11.42  3.71 <0.01  0.05
DE (MJ/kg DM) 15.63 16.64 15.96 15.08 14.96 15.31 13.64 15.01 15.28  5.72 13.86 13.66 13.39 13.06 14.27 13.31 13.27 13.55  3.06 <0.01  0.02
ME, MJ/kg DM 14.92 15.71 15.08 14.04 14.43 14.47 13.22 14.82 14.59  5.10 13.40 12.93 12.86 12.49 13.73 12.56 12.48 12.92  3.74 <0.01  0.48
ATTD of GE (%) 85.17 90.72 87.87 82.30 86.83 81.46 75.67 79.90 83.74  5.79 79.65 73.58 71.02 77.61 74.65 70.32 69.16 73.71  5.28 <0.01  0.03
ME/DE (%) 95.48 94.36 94.51 93.13 96.43 94.50 96.88 98.72 95.50  1.86 96.68 94.71 95.99 95.66 96.21 94.36 94.03 95.38  1.06  0.14  0.16
abcd

Samples from different flour mills in a province.

1

15 samples from 15 wheat flour mills in 10 provinces (HEN = He’nan, HEB = Hebei, LN = Liaoning, SX = Shanxi, XJ = Xinjiang, JS = Jiangsu, GS = Gansu, SC = Sichuan, FJ = Fujian, HUB = Hubei).

2

Mean: 5 observations.

3

CV = Coefficient of variation.

4

p-value: Overall = p-value for the comparison of diets containing 15 ingredients; WS vs RD = Comparison of the wheat shorts and red dog ingredients.

Table 5

Prediction of energy value (MJ/kg of DM) from chemical composition (% of DM) in wheat shorts and red dog

No. Regression equations R2 p-value RSD1
1 DE=0.13×NDF+1 6.92  0.84 <0.01  0.43
2 DE=0.60×Starch+11.26  0.77 <0.01  0.52
3 DE=4.60×CF+16.51  0.75 <0.01  0.55
4 DE=9.90×Ash+16.75  0.75 <0.01  0.54
5 DE=2.91×Xylans+16.31  0.72 <0.01  0.58
6 DE=0.18×NDF+0.20×ADF+16.97  0.87 <0.01  0.41
7 ME=0.11×NDF+16.01  0.76 <0.01  0.50
8 ME=0.07×ND F0.12×Xylans+15.98  0.80 <0.01  0.46
9 ME=0.09×NDF0.16×Xylans+0.20×CP+13.28  0.85 <0.01  0.46
10 ME=0.06×NDF0.16×Xylans+0.26×CP2.02×P+12.73  0.88 <0.01  0.37
11 ME=0.92×DE+0.44  0.96 <0.01  0.15
1

RSD = The root mean square of the error that applies to the whole model.

Table 6

Chemical analysis of ten samples of wheat shorts and red dog used in Exp. 2 (%, DM)1

Item (%) Wheat red dog
Mean2 CV3 Wheat shorts
Mean CV
HLJ HEB LN SX XJ GS SC HEN SD HUB
CP 14.99 14.70 13.95 16.14 16.40 15.24  6.70 17.76 15.43 19.41 18.76 18.42 17.96  8.53
NDF  8.54  9.37 11.11 16.66 20.79 13.29 39.50 29.62 21.21 25.58 25.07 26.68 25.63 11.84
ADF  1.40  1.60  2.31  3.54  4.49  2.67 49.43  6.68  4.80  5.73  6.37  3.81  5.48 21.49
Crude fiber  1.46  1.98  2.55  2.92  4.34  2.65 41.35  4.91  5.04  5.12  5.94  6.75  5.55 14.09
Calcium  0.04  0.03  0.02  0.06  0.09  0.05 55.50  0.08  0.06  0.07  0.09  0.06  0.07 18.11
Phosphorus  0.23  0.22  0.27  0.32  0.53  0.31 43.80  0.41  0.45  0.52  0.57  0.71  0.53 22.02
Indispensable amino acids
 Arginine  0.57  0.73  0.62  0.81  0.95  0.74 20.64  1.03  0.75  1.11  0.97  1.01  0.97 13.88
 Histidine  0.33  0.34  0.31  0.37  0.38  0.35  8.33  0.43  0.36  0.44  0.43  0.44  0.42  8.07
 Isoleucine  0.45  0.47  0.43  0.50  0.49  0.47  6.12  0.50  0.49  0.56  0.55  0.56  0.53  6.43
 Leucine  0.99  0.99  0.91  1.06  1.02  0.99  5.54  1.09  1.03  1.17  1.14  1.19  1.12  5.75
 Lysine  0.36  0.47  0.41  0.54  0.62  0.48 21.50  0.67  0.53  0.75  0.61  0.60  0.63 13.07
 Methionine  0.22  0.25  0.24  0.28  0.27  0.25  9.47  0.28  0.27  0.32  0.29  0.29  0.29  6.45
 Phenylalanine  0.67  0.65  0.63  0.66  0.66  0.65  2.32  0.65  0.70  0.78  0.78  0.73  0.73  7.61
 Threonine  0.39  0.43  0.39  0.49  0.50  0.44 12.03  0.54  0.49  0.60  0.54  0.55  0.54  7.19
 Tryptophan  0.18  0.17  0.16  0.21  0.20  0.18 11.27  0.24  0.20  0.26  0.17  0.21  0.22 16.24
 Valine  0.62  0.65  0.58  0.68  0.74  0.65  9.28  0.74  0.73  0.90  0.78  0.77  0.78  8.68
 Lys/CP3  2.92  3.20  3.80  2.36  3.36  3.13 17.04  3.44  3.30  3.24  3.86  3.77  3.52  7.91
1

Wheat shorts and red dog samples were collected in 10 provinces (HLJ = Heilongjiang, HEB = Hebei, LN = Liaoning, SX = Shanxi, XJ = Xinjiang, GS = Gansu, SC = Sichuan, HEN = He’nan, SD = Shandong, HUB = Hubei).

2

Mean: 5 observations.

3

CV = Coefficient of variation.

4

LYS/CP = Lysine concentration per unit of crude protein (g/100 g of crude protein).

Table 7

Ingredient of composition of experimental diets in Exp. 2 (%, as-fed)

Ingredient (%) Wheat shorts or red dog diet Nitrogen-free diet
Wheat shorts or red dog 60.00 -
Corn starch 24.30 73.35
Sucrose 10.00 15.00
Cellulose acetate1 -  4.00
Soybean oil  2.00  3.00
Limestone  0.60 -
Dicalcium phosphate  2.00  3.00
Sodium chloride  0.30  0.45
Chromic oxide  0.30  0.30
Potassium carbonate -  0.30
Magnesium oxide -  0.10
Vitamin-mineral premix2  0.50  0.50
1

Made by Chemical Reagents Company, Beijing, China.

2

Provided the following per kilogram of diet: Mn, 50 mg as MnO; Fe, 125 mg as FeSO4•H2O; Zn, 125 mg as ZnO; Cu, 150 mg as CuSO4•5H2O; I, 50 mg as CaI2; Se, 0.48 mg as Na2SeO3, retinyl acetate, 4,500 IU; cholecalciferol, 1,350 IU; DL-a-tocopheryl acetate, 13.5 mg; menadione sodium bisulfite complex, 2.7 mg; niacin, 18 mg; vitamin B12, 27.6 μg; thiamine, 0.6 mg; pyridoxine, 0.9 mg; riboflavin, 1.8 mg; D-ca-pantothenate, 10.8 mg; nicotinic acid, 30.3 mg; choline chloride, 210 mg.

Table 8

Analyzed composition of experimental diets used in Exp. 2 (% DM)

Item (%) Wheat red dog diets
Mean CV2 Wheat shorts diets
Mean CV
HLJ HEB LN SX XJ GS SC HEN SD HUB
CP  8.70  8.74  8.21  9.39  9.79  8.97  6.95  9.97  9.92 11.01 11.03 10.73 10.53  5.21
NDF  6.30  7.72 16.64 13.70 16.04 12.08 39.60 17.79 15.66 15.40 16.25 19.73 16.97 10.62
ADF  1.35  1.27  2.17  2.42  3.17  2.08 38.09  2.31  3.80  4.24  3.64  4.91  3.78 25.34
Indispensable amino acids
 Arginine  0.52  0.42  0.38  0.61  0.58  0.50 19.84  0.62  0.65  0.46  0.35  0.60  0.54 23.69
 Histidine  0.23  0.20  0.20  0.27  0.25  0.23 13.40  0.26  0.28  0.21  0.18  0.26  0.24 17.43
 Isoleucine  0.31  0.29  0.26  0.31  0.28  0.29  7.31  0.31  0.32  0.29  0.26  0.32  0.30  8.50
 Leucine  0.69  0.61  0.55  0.69  0.61  0.63  9.52  0.69  0.71  0.64  0.59  0.72  0.67  8.11
 Lysine  0.34  0.26  0.25  0.34  0.37  0.31 17.17  0.42  0.42  0.30  0.20  0.37  0.34 27.30
 Methionine  0.17  0.15  0.13  0.17  0.17  0.16 11.32  0.17  0.18  0.16  0.14  0.19  0.17 11.45
 Phenylalanine  0.42  0.37  0.31  0.44  0.37  0.38 13.27  0.41  0.43  0.43  0.38  0.45  0.42  6.30
 Threonine  0.31  0.26  0.25  0.33  0.30  0.29 11.69  0.34  0.36  0.29  0.24  0.33  0.31 15.27
 Tryptophan  0.11  0.10  0.08  0.12  0.11  0.10 14.58  0.12  0.13  0.12  0.09  0.14  0.12 15.59
 Valine  0.45  0.36  0.36  0.47  0.40  0.41 12.43  0.49  0.47  0.40  0.34  0.45  0.43 14.05
1

Wheat shorts and red dog samples were collected in 10 provinces (HLJ = Heilongjiang, HEB = Hebei, LN = Liaoning, SX = Shanxi, XJ = Xinjiang, GS = Gansu, SC = Sichuan, HEN = He’nan, SD = Shandong, HUB = Hubei) Values are means for 6 observations.

2

CV = Coefficient of variation.

Table 9

Apparent ileal digestibility (%) of dry matter, crude protein and amino acids in wheat shorts and red dog tested in Exp. 2 (% as fed)

Item (%) Wheat red dog
Mean CV2 Wheat shorts
Mean CV p-value3
HLJ HEB LN SX XJ GS SC HEN SD HUB Overall WS vs RD
Crude protein 74.83 77.45 77.53 75.93 76.78 76.50  1.48 80.15 76.58 79.43 80.33 77.58 78.81  2.10 <0.01  0.32
Dry matter 81.09 87.06 83.59 76.23 78.92 81.38  5.13 78.87 78.69 83.29 85.26 76.15 80.45  4.62 <0.01  0.81
Indispensable amino acids
 Arginine 82.08 88.90 87.90 85.46 89.73 86.81  3.56 91.98 86.48 88.35 91.20 88.53 89.31  2.52 <0.01 <0.01
 Histidine 81.81 87.59 85.92 84.20 84.64 84.83  2.53 87.22 83.63 87.06 87.05 83.99 85.79  2.11 <0.01 <0.01
 Isoleucine 80.79 86.30 82.91 83.74 83.85 83.52  2.37 86.87 83.58 85.82 84.49 82.53 84.66  2.04  0.02  0.05
 Leucine 85.04 88.41 85.77 86.00 85.64 86.17  1.51 88.57 85.35 87.81 86.50 84.92 86.63  1.80  0.01  0.04
 Lysine 65.66 78.69 75.11 75.92 83.52 75.78  8.63 86.28 76.31 81.86 80.27 76.88 80.32  5.05 <0.01  0.02
 Methionine 89.82 88.86 87.37 88.28 89.27 88.72  1.06 90.53 85.87 85.84 87.35 87.07 87.33  2.19  0.02  0.23
 Phenylalanine 87.87 89.23 86.49 88.30 86.38 87.65  1.39 89.04 85.98 88.49 87.69 86.90 87.62  1.40  0.02  0.09
 Threonine 65.50 74.34 68.19 70.61 71.37 70.00  4.77 78.07 71.46 77.86 74.98 71.48 74.77  4.35 <0.01  0.03
 Tryptophan 80.60 81.04 78.83 81.49 80.75 80.54  1.26 79.60 77.42 79.18 81.74 78.00 79.19  2.11  0.02  0.44
 Valine 77.70 84.02 81.38 81.02 82.88 81.40  2.94 87.36 81.67 84.19 84.05 82.20 83.89  2.66 <0.01  0.02
1

Wheat shorts and red dog samples were collected in 10 provinces (HLJ = Heilongjiang, HEB = Hebei, LN = Liaoning, SX = Shanxi, XJ = Xinjiang, GS = Gansu, SC = Sichuan, HEN = He’nan, SD = Shandong, HUB = Hubei). Values are means for 6 observations.

2

CV = Coefficient of variation.

3

p-value: Overall = Comparisons among 10 wheat shorts and red dog. WS vs RD = Comparison of the wheat shorts and red dog ingredients.

Table 10

Standardized ileal digestibility (%) of crude protein and amino acids in wheat shorts and red dog tested in Exp. 2 (% as fed)1

Item (%) Wheat red dog
Mean CV2 Wheat shorts
Mean CV p-value3
HLJ HEB LN SX XJ GS SC HEN SD HUB Overall WS vs RD
Crude protein 89.25 91.20 89.31 90.02 92.84 90.52  1.67 90.94 90.47 93.97 93.42 90.37 91.83  1.88 <0.01  0.62
Indispensable amino acids
 Arginine 90.32 92.58 96.78 91.68 94.70 93.21  2.74 95.96 92.06 92.86 95.92 96.49 94.66  2.15 <0.01  0.39
 Histidine 90.57 92.04 95.04 93.27 92.62 92.71  1.77 95.34 91.99 92.94 93.39 95.83 93.90  1.74 <0.01  0.75
 Isoleucine 87.61 90.49 92.71 91.97 92.32 91.02  2.29 93.78 91.08 91.26 92.07 94.26 92.49  1.57 <0.01  0.48
 Leucine 91.51 92.29 94.99 93.71 93.56 93.21  1.45 94.75 92.48 93.24 93.63 94.88 93.80  1.09 <0.01  0.53
 Lysine 79.54 86.63 88.72 85.33 91.39 86.32  5.13 94.41 84.81 88.30 88.29 90.36 89.23  3.94  0.02  0.69
 Methionine 95.26 92.12 93.53 92.98 93.95 93.57  1.25 94.49 90.43 89.35 91.98 94.66 92.18  2.58  0.01  0.12
 Phenylalanine 93.03 92.94 95.00 94.35 92.12 93.49  1.24 95.62 92.03 93.34 93.90 96.07 94.19  1.76 <0.01  0.60
 Threonine 82.39 86.63 89.06 87.41 84.78 86.05  2.98 91.10 87.09 90.03 89.36 91.09 89.73  1.84  0.02  0.68
 Tryptophan 88.89 87.22 90.84 90.18 91.06 89.64  1.78 89.13 85.24 85.19 90.48 94.95 89.00  4.57  0.02  0.80
 Valine 87.48 90.17 91.84 89.28 91.14 89.98  1.89 94.96 89.27 90.03 91.97 95.13 92.27  2.94 <0.01  0.21
1

Wheat shorts and red dog samples were collected in 10 provinces (HLJ = Heilongjiang, HEB = Hebei, LN = Liaoning, SX = Shanxi, XJ = Xinjiang, GS = Gansu, SC = Sichuan, HEN = He’nan, SD = Shandong, HUB = Hubei). Values are means for 6 observations.

2

CV = Coefficient of variation.

3

p-value: Overall = Comparisons among 10 wheat shorts and red dog. WS vs RD = Comparison of the wheat shorts and red dog ingredients.

Table 11

Prediction of amino acid digestibility (% as fed) from chemical composition (% of DM) in wheat shorts and red dog

No. Regression equations1 R2 p-value RSD2
1 AIDN=0.67×CP+66.54  0.47 <0.05  1.25
2 AIDLYS=11.4×LYS/CP+40.13  0.83 <0.01  2.23
3 AIDTHR=1.59×CP+49.14  0.63 <0.01  2.76
4 AIDMET=0.41×CF+89.69  0.20 NS3  1.35
5 SIDN=0.73×CP+79.01  0.64 <0.01  0.96
6 SIDLYS=6.41×LYS/CP+66.46  0.51 <0.01  2.71
7 SIDTHR=0.99×CP+73.45  0.37 <0.05  2.12
8 SIDMET=0.69×CF+95.11  0.41  0.05  1.41
1

AID N = Apparent ileal digestibility of nitrogen, AID LYS = Apparent ileal digestibility of lysine, AID THR = Apparent ileal digestibility of threonine, AID MET = Apparent ileal digestibility of methionine, SID N = Standardized ileal digestibility of nitrogen, SID LYS = Standardized ileal digestibility of lysine, LYS/CP = Lysine concentration per unit of crude protein (g/100 g of crude protein), SID MET = Standardized ileal digestibility of methionine, SID THR = Standardized ileal digestibility of threonine.

2

RSD = The root mean square of the error that applies to the whole model.

3

NS = Not significant.